中效过滤棉，顶棚棉，顶棉，烤漆房过滤棉

产品特性：

1、应用表面涂装行业，专门为喷漆室末端过滤而设计,由抗断裂的合成纤维构成的高性能热熔法无纺布加工而成。

2、往纯净空气方向的纤维密度逐渐增大，较高过滤效率，延长使用寿命；

3、因粘剂完全渗透介质而使尘埃粒子无法通过;得到全面过滤的空气均匀扩散.形成层流状态,达到最佳的喷涂效果;产品的出风面附有精编网来加固和延长使用寿命。这样既能保证稳定的过滤效率和容尘量，又不会使阻力太高。降低了使用和维护费用。

4、可达100%相对耐湿度；符合防火分类标准欧洲DIN53438-Fl；

使用条件：

为正确使用好产品，确保烤漆质量，必须注意以下事项：在更换产品时，先将进风口，顶棚、底板滤网拆除，将通风管道，阴暗角落及易积灰尘处认真进行清理，然后关上烤漆房门，打开风机空吹1小时左右，打扫干净后，再安装滤棉，安装滤棉时，滤料与框架和周遍不得留有任何空隙，先将顶棚及进风口滤棉装上，打开风机空吹4小时左右，再进行一次清洁工作后，装上地棉，方可使用。

使用范围：

安装在汽车装配车间或汽车喷漆烤漆车间，作为顶棚滤棉。安装在汽车表面整修部门的喷漆、烤漆房的顶棚，作为通风设备的最终空气供给过滤棉。安装在要求高度光泽和高科技抛光处理产品的生产车间和喷漆房中作为最终空气供给过滤棉。

KF-600G Ceiling Filter, Roof Filter, Spray Booth Filter

1. Medium efficiency filter media is widely used in coating industry and specially designed for the terminal filtration of paint spray booths. This filter media is made of anti-fracture synthetic fiber with high performance by the hot-melted non-woven.

2. The density of the synthetic fiber is progressive structured by the clean air way with higher filter efficiency and longer working life.

3. The adhesive impregnate the filter media so that make the dust and particle cannot be through in order to diffuse the filtered air equally and inform the laminar flow reaching the best paint and spray effect. The air outlet side is with the meshes to strengthen and longer the working life. In that case the filter efficiency and dust holding can be insured and firmed so that the pressure will not be high and the using and maintaining cost will be lower.

4. The relative humidity is up to 100% and conformed to the DIN53438 Non-flammability Standard-F1

Conditions of Usage:

In order to use this filter media in the right way and insure the quality of the painting, the following items should be paid attention to: When replacing the filters, the air inlet, ceiling and the button board filter mesh should be removed. And the ventilation pipe, the dark corners and the dust holding places should be cleaned. Then the spray booth should be closed and the fans open to blow for about one hour. After cleaning, the filter media is installed. When installing, there must be no any opening between filter media and frame or other surroundings. More 4 hours’ fan blowing is needed after installing. And one more cleaning is needed after the installing of floor filter.

Applications:

Medium efficiency filter installed in the automobile assembling plants and auto paint spray booths as the ceiling filters. Installed at the ceiling of the spray booth for automobile surface coating and repair departments, worked as the filter media for the terminal ventilation device. This filter media is installed as the air filter supplies for the factories and paint spray booths in great needs of high gloss and high-tech polishing treatment.